NDSU Extension Service - Mercer County

Accessibility


| Share

Spring Grain Drying and Storage Critical

Storing grain, drying grain

Submitted by Craig Askim, Extension Agent, Agriculture and Natural Resources

As outdoor temperatures increase, stored grain requires attention to prevent losses, says Ken Hellevang, North Dakota State University Extension Service agricultural engineer and grain drying expert.

The stored grain temperature increases in the spring due to an increase in outdoor temperatures and solar heat gain on the bin. Solar energy produces more than twice as much heat gain on the south wall of a bin in early spring as it does during the summer.

Periodically run aeration fans to keep the grain temperature below 30 degrees until the grain is dried if it exceeds recommended storage moisture contents and below 40 degrees during the spring if it is dry. 

Stored grain should be monitored closely to detect any storage problems early, Hellevang advises. Grain temperature and moisture content should be checked every two weeks during the spring and summer. Grain also should be examined for insect infestations. 

Check the moisture content of stored grain to determine if it needs to be dried. Remember to verify that the moisture content measured by the meter has been adjusted for grain temperature. In addition, remember that moisture measurements of grain at temperatures below about 40 degrees may not be accurate. Verify the accuracy of the measurement by warming the grain sample to room temperature in a sealed plastic bag before measuring the moisture content.

Corn needs to be dried to 13 to 14 percent moisture for summer storage to prevent spoilage. Soybeans should be dried to 11 percent, wheat to 13 percent, barley to 12 percent and oil sunflowers to 8 percent.

Propane prices are still high but have moderated somewhat. The cost of high- temperature drying per point of moisture removed using a moderately efficient dryer can be estimated by multiplying the propane price per gallon by 0.02.

For natural air-drying, assure that the airflow rate the fan supplies is at least 1 cubic foot per minute per bushel (cfm/bu) and the initial corn moisture does not exceed 21 percent.

Start drying when the outside air temperature averages about 40 degrees. Below that temperature, the moisture-holding capacity of the air is so small that very little drying occurs. The expected drying time with this airflow rate will be about 50 days. Drying corn during April and early May in North Dakota is similar to natural air-drying during October.

Hellevang recommends an airflow rate of at least 1 cfm/bu to natural air-dry up to 16 percent moisture soybeans. Natural air-drying for oil sunflowers requires an airflow rate of 0.75 cfm/bu for up to 15 percent moisture. The drying should start in early to mid-April, when outdoor temperatures average about 40 degrees.

Use an airflow rate of at least 0.75 cfm/bu to natural air-dry up to 17 percent moisture wheat. Start drying when the outside air temperature averages about 50 degrees. Drying during May is similar to drying wheat and barley during September.

"Remember that some of the allowable storage life was used during the fall before the grain was cooled to near or below freezing, so there is less time for spring drying before deterioration occurs," Hellevang says. "This is particularly important for malting barley, where germination can be lost, so using a higher airflow rate to reduce the drying time is encouraged."

He suggests an airflow rate of at least 0.75 cfm/bu to natural air-dry up to 16 percent moisture barley. Grain storage molds will grow and grain spoilage will occur in grain bags unless the grain is dry. "Also, everyone needs to become aware of safety hazards associated with handling grain and to apply recommended safety practices," Hellevang stresses.

Visit the NDSU Extension Service's postharvest website at http://www.ag.ndsu.edu/graindrying for more information on drying and storing grain.

Source: Ken Hellevang, (701) 231-7243, kenneth.hellevang@ndsu.edu

Creative Commons License
Feel free to use and share this content, but please do so under the conditions of our Creative Commons license and our Rules for Use. Thanks.